Bennett Sizing

Call toll free - (877) 379-2248

Trim Tab Kits
Trailered Boats 17'-23'
Bass Boats
High Performance Boats
Standard Trim Tabs

Bennett Marine
Sizing Guidelines

Many factors affect the choice of properly sized trim tabs, and the ultimate responsibility for selection is up to the boat owner. These sizing recommendations are based on average performance. Your choice may vary based on power, engine configuration, weight distribution, type of boat, and use. When making a choice between trim tab sizes, remember that the largest trim tabs that will comfortably fit on the transom will be the most efficient.

Bennet Trim Tab Sizing

Boat Length	Engine Configuration	Tab Size
15' - 19'	Single I/O, Single Outboard, or Inboard	12" x 9"
17' - 20'	M80 Sport Tab for Trailered Boats	8" x 10"
19' - 24'	Single I/O, Single Outboard, or Inboard	18" x 9"
20' - 23'	M120 Sport Tab for Trailered Boats	10" x 12"
19' - 24'	Limited Transom Space or Extra Lift	12" x 12"
22' - 27'	Single I/O or Single Outboard	24" x 9"
22' - 27'	Twin I/O or Twin Outboard	18" x 12"
25' - 30'	Single I/O or Single Outboard	30" x 9"
25' - 30'	Limited Transom Space or Extra Lift	30" x 12"
25' - 30'	Twin I/O or Twin Outboard	24" x 12"
28' - 34'	Inboard	36" x 9"
28' - 34'	Limited Transom Space or Extra Lift	36" x 12"
28' - 34'	Twin I/O or Twin Outboard	24" x 12"
32' - 38'	Inboard	42" x 9"
32' - 38'	Limited Transom Space or Extra Lift	42" x 12"
36' - 44'	Inboard	48" x 9"
36' - 44'	Limited Transom Space or Extra Lift	48" x 12"
42' - 50'	Inboard	54" x 9"
50' - 60'	Inboard	54" x 12"
60' - 65'	Inboard	60" x 12"
65' - 70'	Inboard	66" x 12"
70' - 80'	Inboard	72" x 12"

General Guidelines
Choose at least one inch of trim tab span (per side) for every foot of boat length. (Examples: 22 foot boat = no less than 24" x 9", 36 foot boat = no less than 36" x 9")
Span = side to side measurement
Chord = fore to aft measurement

Measuring
After choosing a general trim tab size (see chart below), double check the size by measuring the transom using the diagrams. When measuring, disregard the strakes and follow the Vee of the hull.

12" Chord
The 9" chord is used in most applications. However, in certain applications the 12" chord may be more effective: Limited Transom Space Boats with twin outboards or twin I/Os, or boats with transom configurations that limit trim tab span can use 12" chord tabs to achieve maximum lift in minimum area. Using the measuring guideline above, fit the maximum span trim tab and use the 12" chord. Extra Lift Slower boats (less than 15 mph), semi-displacement hulls, boats over 50 feet, outboards on brackets, or boats with any other feature that increases the need for lift aft benefit from the 12" chord. The 12" chord provides greater surface area, thereby utilizing more water flow and providing more lift.

Installation Requirements
Trim tabs should follow the Vee at the junction of the transom and the bottom of the boat. For maximum side to side control trim tabs are generally mounted 3 - 4" from the chine and run towards the keel.

In the case of inboards, the complete run from chine to keel may be utilized if it is an unbroken span of the same angle. Protrusions such as strakes may be bridged provided there is no change in angle on both sides.

On boats powered by inboard/outboards (I/O) or outboards it is necessary that the trim tabs not be placed too close (8" minimum) to the lower unit(s) to avoid disturbing the water flow to the propeller.

Performance Boats
Many factors determine the appropriate size and type trim tabs for faster boats. Special consideration is required when selecting trim tabs for performance applications.

You may wish to contact Bennett Marine to discuss your particular application. Bennett Sport Tabs are available for boats in the 40-60 mph range.

Pyacht.com
222 Severn Avenue
Annapolis, MD 21403

Toll free: 1-877-379-2248
Local: (410) 268-9696
Fax: (410) 268-9625

Join our Email List
Enter your email address in the box below and click submit to receive bi-weekly product updates and special offers.

The mark "pyacht.com" and the "pyacht.com" logo are the property of Performance Yacht.com, Incorporated and are registered with the United States Patent and Trademark Office.